Modification of Activated Carbon from Palm Kernel Shells with Fe₃O₄ Magnetic for Water Treatment of Enim River

Damayanti Damayanti, Susila Arita, Poedji Loekitowati Hariani

Abstract


The economical, easy-to-implement, and regenerative treatment methods are essential to obtain clean water. In this study, activated carbon was synthesized from palm kernel shells using ZnCl₂ as an activator. The activated carbon was then modified with Fe₃O₄. The resulting activated carbon and activated carbon-Fe₃O₄ product were characterized using XRD, SEM-EDX, VSM, and BET surface area analysis. Furthermore, activated carbon-Fe3O4 was applied to reduce Fe ions, turbidity, and total suspended solids (TSS) and increase the pH value in Enim river water. The resulting activated carbon has met SNI standards, with a moisture content of 8.81%, ash content of 5.475%, and an iodine adsorption capacity of 1763.86 mg/L. The synthesized activated carbon-Fe₃O₄ exhibits strong magnetic properties, with a saturation magnetization value of 68.82 emu/g and a surface area of 355.42 m²/g. Optimal conditions for the treatment of Enim river water were obtained at an adsorbent dose of 40 mg/L, a stirring rate of 120 rpm, and a stirring time of 120 minutes. Under these conditions, the Fe ion reduction efficiency reached 96.95%, turbidity 89.83%, and TSS 80.74%, while the pH increased from 6.23 to 6.74. FTIR analysis showed a change in peak intensity in the activated carbon-Fe₃O₄ after the adsorption process, indicating interaction with contaminants. The adsorption process of Fe ions by activated carbon-Fe₃O₄ follows a pseudo-second-order kinetic model.

Full Text:

Full text PDF

References


H. S. Majdi, M. S. Jaafar, and A. M. Abe. “Using KDF material to improve the performance of multi-layers filters in the reduction of chemical and biological pollutants in surface water treatment.” South African Journal of Chemical Engineering, vol. 28, pp. 39-45, 2019.

A. Jakubaszek. “Water quality assessment after modernization of the technological system in the water treatment plant in Drzenin (Poland).” Civil and Environmental Engineering Reports, vol. 29(4), pp. 254-266, 2019.

F. Garcia-Avila, A. Aviles-Anazco, E. Sanchez-Cordero, L. Valdiviezo-Gonzales, and M. D. T. Ordonez. “The challenge of improving the efficiency of drinking water treatment

systems in rural areas facing changes in the raw water.” South African Journal of Chemical Engineering, vol. 37, pp. 141-149, 2021.

Subroto, M. Said, E. Ibrahim, and P. L. Hariani. “Performance of coal-based activated carbon modified with NiFe2O4 for raw water treatment.” Journal of Ecological Engineering, vol. 26(1), 173-185, 2025.

L. A, V. Govindaraj, G. Ramachandran, and P. Bermavatu. ”Removal of turbidity from lake water using novel Chrysopogon zizanioides

and Hemidesmus indicus.” Desalination and Water Treatment.” vol. 317, pp. 1-9, 2024.

P. O. Amaeh, M. A. Habila, R. Garg, C. C. Onoyima, G. O. Ihegboro, C. J. Ononamadu, R. Garg, Z. Adamu, U. J. Joel, and R. Showunmi. ”Removal of contaminants from river Jakara using iron oxide nano particles prepared from Citrullus lanatus fruit waste.” Journal of Hazardous Materials Advances, vol. 15, pp. 1-11, 2024.

A. Chiavola, C. D. Marcantonio, M. D’Agostini, S. Leoni, and M. Lazzazzara. ”A combined experimental-modeling approach for turbidity removal optimization in a coagulation–flocculation unit of a drinking water

treatment plant.” Journal of Process Control, vol. 130, pp. 1-10, 2023.

Z. Meldha, I. Amri, M. D. T. Angkoso, Y. Jumaga, and Drastinawati. ”The utilization of silica sand and clay with the addition of sawdust as raw material for manufacturing ceramic membranes to reduce TSS and

TDS levels of peat water.” Materials Today: Proceedings, vol. 87, pp. 415-419, 2023.

N. Bensitel, K. Haboubi, F. Azar, Y. El Hammoundani, A. El abdouni, C. Haboubi, F. Dimane, and A. El Kasmi. ”Potential reuse of sludge from a potable water treatment plant in Al Hoceima city in northern Morocco.” Water Cycle, vol. 4, pp. 154-162, 2023.

J. Rhu, Y. Han, D. Cho, S. Kim, Y. Cho, C. Chan, J. Ahn, and I. Nam. ”Practical application of PAC sludge-valorized biochars to the mitigation of methyl arsenic in wetlands.” Chemical Engineering Journal, vol. 450(3), pp. 1-11, 2022.

A. M. Dietrch, and G. A. Burlingame. ”Critical review and rethinking of USEPA secondary standards for maintaining organoleptic quality of drinking water.” Environmental Science & Technology, vol. 49(2), pp. 708-720, 2015.

H. Daraei, E. Bertone, J. Awad, R. A. Steward, C. W. K. Chow, J. Duan, and J. V. Leeuwen. ”A multi-analytical approach to investigate DOM dynamics and alum dose control in enhanced coagulation process using wide-ranging surface waters.” Journal of Water Process Engineering, vol. 56, pp. 1-15, 2023.

C. Cucarella, C. Montoliu, C. Hermenegildo, R. Saez, L. Manzo, M. D. Minana, and V. Felipo. ”Chronic exposure to aluminum impairs neuronal glutamate-nitric oxide-cyclic GMP pathway.” Journal of Neurochemistry, vol. 70(4), pp. 1609-1614, 1998.

N. Bojanic, J. Milenkovic, D. Stojanovic, M. Milojkovic, N. Djandjic, and M. Gmiijovic. ”Pathophysiological mechanisms of aluminium toxicity.” Acta Medica Medianae, vol. 59(1), pp. 100-109, 2020.

S. Mashhadi, R. Sohrabi, H. Javadian, N. Ghasemi, I. Tyadi, S. Agarwal, and V. K. Gupta. ”Rapid removal of Hg (II) from aqueous solution by rice straw activated carbon prepared by microwave-assisted H2SO4 activation: Kinetic, isotherm and thermodynamic studies.” Journal of Molecular Liquids, vol. 215, pp. 144-153, 2016.

E. M. Mistar, T. Alfatah, and M. D. Supardan. ”Synthesis and characterization of activated carbon from Bambusa vulgaris striata using two-step KOH activation.” Journal of Materials Research and Technology, vol. 9(3), pp. 6278-6286, 2020.

K. K. Kuok, P. C. Chiu, Md. R. Rahman, M. Y. Chin, and N. K. B. Bakri. ”Sustainable bamboo and coconut shell activated carbon for purifying river water on Borneo Islan.” Waste Management Bulletin, vol. 2, pp. 39-48, 2024.

U. D. Hamza, N. S. Nasri, N. S. Amin, J. Mohammed, and H. M. Zain. ”Characteristics of oil palm shell biochar and activated carbon prepared at different carbonization times.” Desalination and Water Treatment, vol. 57, pp. 7999-8006, 2016.

A. C. Lua. ”A comparative study of the pore characteristics and phenol adsorption

performance of activated carbons prepared from oil-palm shell wastes by steam and combined steam-chemical activation.” Green Chemical Engineering, vol. 5, pp. 85-96, 2024.

K. Jasri, A. S. Abdulhameed, A. H. Jawad, Z. A. AlOthman, T. A. Yousef, and O. K. Al Duaij. ”Mesoporous activated carbon produced from mixed wastes of oil palm frond and palm kernel shell using microwave radiation-assisted K2CO3 activation for methylene blue dye removal: Optimization by response

surface methodology.” Diamond & Related Materials, vol. 131, pp. 1-12, 2023.

N. A. El-Sheeta, M. E. Goher, M. G. A. El-Moghny, and M. S. El-Deab. ”Efficient elimination of Pb(II) ions from aqueous solutions using magnetic Fe3O4-nanoparticles/activated carbon derived from agricultural waste.” Desalination and Water Treatment, vol. 258, pp. 241-260, 2022.

S. Afshin, Y. Rashbari, M. Vosough, A. Dargahi, M. Fazizadeh, A. Behzad, and M. Yousefi. ”Application of Box–Behnken design for optimizing parameters of hexavalent chromium removal from aqueous solutions using Fe3O4 loaded on activated carbon prepared from alga: Kinetics and equilibrium study.” Journal of Water Process Engineering, vol. 42, pp. 1-9, 2021.

M. Bagherzadeh, B. Aslibeiki, and N. Arsalani. ”Preparation of Fe3O4/vine shoots derived activated carbon nanocomposite for improved removal of Cr(VI) from aqueous solutions.” Scientific Reports, vol. 13, pp. 1-19, 2023.

SNI 06-3730-1995. ”Arang aktif teknis.” Badan Standarisasi Nasional (BSN), 1995.

A. H. Wazir, I. Ul Hag, A. Manan, and A. Khan. ”Preparation and characterization of activated carbon from coal by chemical activation with KOH.” International Journal of Coal Preparation and Utilization, vol. 42, pp. 1477-1488, 2020.

M. Fan, T. Shao, Y. Wang, J. Sun, H. He, Y. Jiang, S. Zhang, Y. Wang, and X. Hu. ”Preparation of activated carbon with recycled ZnCl2 for maximizing utilization efficiency of the activating agent and minimizing generation of liquid waste.” Chemical Engineering Journal, vol. 500, pp. 1-18, 2024.

P. L. Hariani, M. Faizal, Ridwan, Marsi, and D. Setaibudidaya. ”Removal of Procion red MX-5B from songket's industrial wastewater

in South Sumatra Indonesia using activated carbon-Fe3O4 composite.” Sustainable Environment Research, vol. 28, pp. 158-164, 2018.

C. X. M. Collave, R. J. L. Bacilio, A. E. G. Escobedo, R. F. R. Espinoza, Y. F. A. Liza, and J. M. I. Rona. ”Turbidity and color removal from irrigation water, with coagulants and activated carbon, controlled by an Arduino system.” Case Studies in Chemical and Environmental Engineering, vol. 10, pp. 1-18, 2024

A. K. Badawi, R. Hassan, A. M. Alghamdi, B. Ismail, R. M. Osman, and R. S. Salama. ”Advancing cobalt ferrite-supported activated carbon from orange peels for real pulp and paper mill wastewater treatment.” Desalination and Water Treatment, vol. 318, pp. 1-10, 2024.

Z. Duan, W. Zhang, M. Lu, Z. Shao, W. Huang,

J. Li, Y. Li, J. Mo, Y. Li, and C. Chen. ”Magnetic Fe3O4/activated carbon for combined adsorption and Fenton oxidation of 4-chlorophenol.” Carbon, vol. 167, pp. 351-363, 2020.

J. K. Alagarasan, S. Shasikal, E. R. Rene, P. Bhatt, P. Thangavelu, P. Madheswaran, S. Subramanian, D. D. Nguyen, S. W. Chang, and Moonyong Lee. ”Electro-oxidation of heavy metals contaminated water using banana waste-derived activated carbon and Fe3O4 nanocomposites.” Environmental Research, vol. 215, pp. 1-7, 2022.

I. U. Bakara, M. D. Nurhafizah, N. Abdullah, O. O. Akinnawo, and A. Ul-Hamid. ”Investigation of kinetics and thermodynamics of methylene blue dye adsorption using activated carbon derived from bamboo biomass.” Inorganic Chemistry Communications, vol. 166, pp. 1-11, 2024.

R. Foroutan, R. Mohammadi, J. Razeghi, and B. Ramavandi. ”Performance of algal activated carbon/Fe3O4 magnetic composite for cationic dyes removal from aqueous solutions.” Algae Research, vol. 40, pp. 1-12, 2019.

WHO. ”Guidelines for drinking-water quality.” fourth edition, 2022.

Peraturan Gubernur No. 16 tahun 2005. ”Peruntukan air dan baku mutu air sungai.” 2005.

T. E. Oladimeji, B. O. Odunoye, F. B. Elehinafe, Oyinlola, R. Obanla, Olayemi, and A. Odunlami. ”Production of activated carbon from sawdust and its efficiency in the treatment of sewage water.” Heliyon, vol.7, pp. 1-6, 2021.

K. E. V. Saltos, A. P. Á. Bravo, R. A. C. Mosquera, and M. A. Riera. ”Efficiency of activated carbon derived from cocoa shells in removing pollutants from wastewater.” Journal of Ecological Engineering, vol. 25(7), pp. 151-162, 2024.

P. O. Ameh, M. A. Habila, R. Garg, C. C. Onoyima, G. O. Ihegboro, C. J. Ononamadu, R. Garg, Z. Adamu, U. J. Joel, and R. Showunmi. ”Removal of contaminants from river Jakara using iron oxide nano particles

prepared from Citrullus lanatus fruit waste.” Journal of Hazardous Materials Advances, vol. 15, pp. 1-11, 2024.

P. Chen, X. Zhang, Z. Cheng, Q. Xu, X. Zhang, Y. Liu, and F. Qiu. ”Peroxymonosulfate (PMS) activated by magnetic Fe3O4 doped carbon

quantum dots (CQDs) for degradation of Rhodamine B (RhB) under visible

light: DFT calculations and mechanism analysis.” Journal of Cleaner Production, vol. 426, pp. 1-13, 2023.

W. Purwaningrum, Hasanudin, A. Rachmat, F. Riyanti, and P. L. Hariani. ”Magnetic composite for efficient adsorption of iron and manganese ions from aqueous solution.” Ecological Engineering & Environmental Technology, vol. 24(8), pp. 143-154, 2023.


Refbacks

  • There are currently no refbacks.


 

Editorial Office:

Department of Chemistry, Faculty of Mathematics and Natural Sciences, Universitas Sriwijaya
Jl. Palembang-Prabumulih Km.35 Indralaya Ogan Ilir Sumatera Selatan 30662

 

 

Creative Commons License
IJFAC by Department of Chemistry, Faculty of Mathematics and Natural Sciences, Universitas Sriwijaya is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License