Comparison of Alum and Coal-Based Activated Carbon for the Treatment of Raw Water
Abstract
The availability of clean water is an essential element for supporting the life cycle and sustainable development. The efficiency of providing raw water sources is an important factor for adequate water quantity and quality. This study examines the effectiveness of alum compared with coal-based activated carbon in the removal of Fe, Mn, and turbidity in raw water from the Lematang River, Muara Enim Regency. Activated carbon in this study was produced using a KOH activator with varying activation temperatures (700 °C, 800 °C, and 900 °C). The research results showed that the quality of the third activated carbon met the active carbon quality standards (moisture, ash content, Methylene blue dye and iodine adsorption capacity), but the activated carbon with activation at a temperature of 800 °C had the largest surface area. Activated carbon was proven more effective in reducing Fe and Mn concentrations than alum, while alum was superior in reducing turbidity. After three cycles of activated carbon regeneration, the reduction in Fe and Mn remained below 5%. These results show that activated carbon is a cost-effective and eco-friendly option for raw water treatment.
Keywords: Coal, activated carbon, alum, raw water, regenerationFull Text:
Full-text PDFReferences
J. Hoslett, T.M. Massara, S. Malami, D. Ahmad, I.V. Boogaert, E. Katsou, B. Ahmad, H. Ghazal, S. Simons, L. Wrobel, H. Jouhara. “Surface water filtration using granular media and membranes: A review.” Science of The Total Environment, vol. 639, pp. 1268-1282, 2018
M.A. El-Alfy, A.F. Hasballah, H.T.Abd El-Hamid, A.M. El-Zeiny. “Toxicity assessment of heavy metals and organochlorine pesticides in freshwater and marine environments, Rosetta area, Egypt using multiple approaches.” Sustainable Environment Research, vol. 29(19), pp. 1-12, 2019
A. Bahadori, M. Clark, B. Boyd. “Essentials of Water Systems Design in the Oil, Gas, and Chemical Processing Industries.” Springer, New York, 2013
N.P. Sanchez, A.T. Skeriotis, C.M. Miller. “A PARAFAC-based long-term assessment of DOM in a multi-coagulant drinking water treatment scheme.” Environmental Science & Technology Journal, vol. 48(3), pp. 1582–1591, 2014
K. Gurumath, S. Suresh. “Cicer arietinum is used as natural coagulant for water treatment.” IRJET- International Research Journal of Engineering and Technology, vol. 6, pp. 2930–2931, 2019
E.E. Lavonen, D.N. Kothawala, L.J. Tranvik, M. Gonsior, P. Schmitt-Kopplin, S.J. Kohler. “Tracking changes in the optical properties and molecular composition of dissolved organic matter during drinking water production.” Water Research, vol. 85, pp. 286-294, 2015
I.B. Obinnaa, E.C. Ebere. “A Review: Water pollution by heavy metal and organic pollutants: Brief review of sources, effects, and progress on remediation with aquatic plants.” Analytical Methods in Environmental Chemistry Journal, vol 2. pp. 5-38, 2019
Y. El Mouzdahir, A. Elmchaouri, R. Mahboub, A. Gil, S.A. Korili. “Equilibrium modeling for the adsorption of methylene blue from aqueous solutions on activated clay minerals.” Desalination, vol. 250, pp. 335-338, 2010
L. Kumar, R. Kaur, J. Sharma. “The efficiency of zeolites in water treatment for combating ammonia – An experimental study on Yamuna River water & treated sewage effluents.” Inorganic Chemistry Communications, vol. 134, pp. 1-10, 2021
T.E. Oladimeji, B. O. Odunoye, F.B. Elehinafe, Oyinlola, R. Obanla, Olayemi, A. “OdunlamiProduction of activated carbon from sawdust and its efficiency in the treatment of sewage water.” Heliyon, vol. 7, pp. 1-6, 2021
N. Zaki, N. Hadoudi, N. Bensitel, A. Salhi, H. Amhadi, M. Ahari. “Assessing the efficacy of bentonite as a coagulant aid for raw water treatment.” Desalination and Water Treatment, vol. 311, pp. 45-53, 2023
M. Kaleem, L.A. Minhas, M.Z. Hashmi, H.M.U. Farooqi, R. Waqar, K. Kamal, R.S. Aljaluod, K.M. Alatjani, A. S. Mumtaz. “Biogenic synthesis of iron oxide nanoparticles and experimental modeling studies on the removal of heavy metals from wastewater.” Journal of Saudi Chemical Society, vol. 28, pp. 1-10, 2024
M.A. Yahya, M.H. Mansor, W.A.A.W. Zolkarnaini, N.S. Rusli, A. Aminuddin, K. Mohamad, F.A.M. Sabhan, A.A.A. Atik, L.N. Ozair. “A brief review on activated carbon derived from agriculture by-product.” In AIP Conf. Proc. 2018, vol. 1072, pp. 1-8
E.M. Mistar, T. Alfatah, M.D. Supardan. “Synthesis and characterization of activated carbon from Bambusa vulgaris striata using two-step KOH activation.” Journal of Materials Research and Technology, vol. 9(3), 6278-6286, 2020
R. Zhao, J. Hao, X. Yang, Y. Zhao, J. Chen, J. Guo, C. Chi, Q. Guo. “FeCl3 induced catalytic activation prepared porous carbon with carbon nanotube skeleton from coal for supercapacitor electrodes.” Journal of Power Sources, vol. 623, pp. 1-11, 2024
Z.Y. Atiyah, S.K. Muallah, A.H. Abbar. “Removal of COD from petroleum refinery wastewater by adsorption using activated carbon derived from avocado plant.” South African Journal of Chemical Engineering, vol. 48, pp. 467-483, 2024
J. Liang, C. Li, S. Zhang, S. Wang, X. Hu. “Sequential activation of willow wood with ZnCl2 and H3PO4 drastically impacts pore structure of activated carbon.” Industrial Crops & Products, vol. 221, pp. 1-17, 2024
Y. Guo, Q. Wang. “Exploring the adsorption potential of Na2SiO3-activated porous carbon materials from waste bamboo biomass for ciprofloxacin rapid removal in wastewater”. Environmental Technology & Innovation, vol. 32, pp. 1-15, 2023
S. Sagadevan, T. Balakrishnan, Md. Z. Rahman, T. Soga, H. Randrianmahazaka, B. Kakavandi, M.R. Johan. “Agricultural biomass-based activated carbons for efficient and sustainable supercapacitors.” Journal of Energy Storage, vol. 97, pp. 1-24, 2024.
L.U. Bakara, M.D. Nurhafizah, N. Abdullah, O.O. Akinnawo, A. UI-Hamid. “Investigation of kinetics and thermodynamics of methylene blue dye adsorption using activated carbon derived from bamboo biomass.” Inorganic Chemistry Communications, vol. 166, pp. 1-11, 2024
Subroto, M. Said, E. Ibrahim, P.L. Hariani. “Performance of coal-based activated carbon modified with NiFe2O4 for raw water treatment.” Journal of Ecological Engineering, vol. 26(1), pp. 173-185, 2025
Y. Mi, W. Wang, S. Zhang, Y. Guo, Y. Zhao, G. S, Z. G. “Ultra-high specific surface area activated carbon from Taihu cyanobacteria via KOH activation for enhanced methylene blue adsorption.” Chinese Journal of Chemical Engineering, vol. 67, pp. 1-11, 2024
X. Gao, Y. Ju, Gefei, H., C. Liu. “Efficient treatment of coking wastewater by coal-based activated carbon prepared through coal blending method.” Colloids and Surfaces A: Physicochemical and Engineering Aspects, vol. 705, pp. 1-9, 2025
P. Manasa, S. Sambasivam, F. Ran. “Recent progress on biomass waste derived activated carbon electrode materials for supercapacitors applications-a review.” Journal of Energy Storage, vol. 54, pp. 1-29, 2022
L. Luo, Y. Lan, Q. Zhang, J. Deng, L. Luo, Q. Zeng, H. Gao, W. Zhao. “A review on biomass-derived activated carbon as electrode materials for energy storage supercapacitors.” Journal of Energy Storage, vol. 55, pp. 1-22, 2022
J. Yang, J. Peng, Y. Lei, Y. Tang, P. Liu, J. Zeng, C. Yi, Y. Shen, L. Zheng, X. Wang. “Activated carbon derived from the agricultural waste camellia seed shell for high performance supercapacitors,” ACS Applied Energy Materials Journal, vol. 7, pp. 469-478, 2024
W. Spencer, G. Senanayake, M. Altarawneh, D. Ibana, A.N. Nikoloski. “Review of the effects of coal properties and activation parameters on activated carbon production and quality.” Minerals Engineering, vol. 212, pp. 1-14, 2024.
Wang, M., Roberts, D.G., Kochanek, M.A., Harris, D.J., Chang, L., Li, C.-Z., 2014. “Raman spectroscopic investigations into links between intrinsic reactivity and char chemical structure.” Energy Fuel, vol. 28 (1), pp. 285–290, 2014
S. Tolouei, J.-B. Burnet, L. Autixier, M. Taghipour, J. Bonsteel, S.V. Duy, S.Sauvé, M. Prévost, S. Dorner, Temporal variability of parasites, bacterial indicators, and wastewater micropollutants in a water resource recovery facility under various weather conditions, Water Research, vol. 148, pp. 446-458, 2019
D.P.W. Sheng, B. Muhammad Roil, S. Norazanita. “Assessment and optimization of coagulation process in water treatment plant: A review,” ASEAN Journal of Science and Engineering, vol. 3, pp. 79-100, 2023
Dharsana, M, A.J. Prakash. “Nano-banana peel bio-coagulant in applications for the treatment of turbid and river water.” Desalination and Water Treatment, vol. 294, pp. 100–110, 2023
A. Chiavola, C. D. Marcantonio, S. Leoni, M. Lazzazzara. “A combined experimental-modeling approach for turbidity removal optimization in a coagulation-flocculation unit of a drinking water treatment plant.” Journal of Process Control, vol. 130, pp. 1-10, 2023
Y. Wang, G. Wu, Y. Zhang, Y. Su, H. Zhang. “The deactivation mechanisms, regeneration methods and devices of activated carbon in applications.” Journal of Cleaner Production, vol. 476, pp. 1-26, 2024.
DOI: http://dx.doi.org/10.24845/ijfac.v10.i1.23
Refbacks
- There are currently no refbacks.
Editorial Office:
Department of Chemistry, Faculty of Mathematics and Natural Sciences, Universitas Sriwijaya
Jl. Palembang-Prabumulih Km.35 Indralaya Ogan Ilir Sumatera Selatan 30662
IJFAC by Department of Chemistry, Faculty of Mathematics and Natural Sciences, Universitas Sriwijaya is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License